How much does it cost to rebuild a e40d transmission?

You can figure $2,000 to $2,500. You may be able to save money by pulling it and installing it yourself. If you decide to do so, check with the rebuilder to see if there is any warranty which could be adversly affected by a home installation. Cost of E4OD Rebuild?

Is the E4OD a good transmission?

They are a good transmission and will run many, many miles if cared for and maintained and not overheated or overloaded.

How much does it cost to rebuild E4OD?

$1000 to about $3500 clams to rebuild the E4OD. The heavy duty or extreme rebuilds will be on the high end of the scale. This type of rebuild will be all new parts. Steels, frictions, seals, gear train ect.

How long does it take to rebuild an E4OD?

It took Phil about six hours to handle our E4OD heavy-duty overhaul. Gary says the cost of such a rebuild would typically run between $1,800-$2,800 depending on the performance level of the rebuild, the year, and condition of the original parts.

IT IS INTERESTING:  Quick Answer: How do you put fluid in a manual transmission?

How do I know if my transmission is e40d?

You can measure the transmission fluid pan to determine which transmission you have if identification information is not available. A 4R70W transmission pan has an overall length of just under 15 inches, while an E4OD pan is much larger, measuring about 20 inches in overall length.

Which is better E4OD or 4R100?

Yes it would fit, the only difference is that the 4r100 has some updates from the E4OD, otherwise they are the exact same. The Solenoid connector plug may be a little different on outer housings.

Can I replace a E4OD with a 4R100?

The 4R100 was introduced as the replacement for the E4OD and was internally stronger for use in the Powerstroke Diesel trucks. While almost identical on the exterior, not all parts are interchangeable between these two units, so care must be exercised to insure compatibility.

What vehicles have the E4OD transmission?

The E4OD was introduced in 1989 and used in both light and heavy duty applications.


  • 1990–1996 Ford Bronco.
  • 1989–1998 Ford E-Series.
  • 1997–1998 Ford Expedition.
  • 1989–1998 Ford F-Series.
  • 1993–1995 SVT Lightning.

How many gears does a e40d have?

Ford E4OD Transmission Specs

Transmission: Ford E4OD
Features: E Electronically controlled
4 Four forward gears
OD Overdrive transmission

What transmission fluid does a E4OD take?

Ford E4OD Transmission Specs

Transmission: Ford E4OD
ATF Type/Spec: Ford MERCON V automatic transmission fluid
Transmission Filter P/N: 2WD applications Motorcraft FT-113
4WD applications Motorcraft FT-114
Fluid Capacity: ~ 17 – 18 quarts

Is it hard to rebuild an E4OD?

Anyone that even attempts to rebuild an E4OD themselves already has a few screws loose or is a glutton for punishment. E4OD’s are EXTREMELY complicated units with many various (and expensive) components that MUST be replaced for it to work correctly (not to “work”, but to work “correctly”).

IT IS INTERESTING:  Your question: How do you stop windshield wipers from making noise?

What’s the difference between E4OD and 4R100?

The Ford E4OD and 4R100 four-speed automatic transmissions were essentially the same transmission with different names. Ford also matched the 4R100 with larger diesel-powered engines. … The E4OD replaced the venerable Ford C-6 automatic transmissions.

How long will a 4R100 transmission last?

I consider the life of a 4R100 to be about 120K miles. If this truck you are looking at has 200K, them most likely it has had a new transmission at some point. I’ve heard of them lasting that long, but not very often. If it breaks, it will cost around 2000-2500 for a shop to rebuild it for you.

How do I identify my transmission?

Open the driver’s side door and find the white card on the side of the door that is filled with small black lettering. This card contains specific details about the year the car was made, its transmission, engine specifications and other details. Underneath or beside the “TR” symbol will be a number code.

Service station