How much does it cost to replace a fan motor?

What’s the Cost of Repairing or Replacing a Fan Motor? The average cost of a condenser fan motor repair is between $300 and $500. This price includes both the price of the part and the labor to have it installed. However, it needs to be replaced right away to prevent further damage to the compressor.

How much should it cost to replace AC fan motor?

When your air conditioner’s fan motor breaks, it will typically cost about $300 to $600 to replace. It’s imperative to get this fixed quickly, since without a working fan motor your air conditioner’s compressor can be the next domino to tumble. Its repair is even more significant — usually running closer to $2,000.

How do I know if my fan motor is bad?

Signs and Symptoms of a Bad AC Fan Motor

  1. The fan won’t start even though the AC is on.
  2. The fan won’t stop, even when you shut the AC off.
  3. The fan turns on, yet the blades are rotating very slowly.
  4. There’s a rattling noise coming from the condenser unit when the fan is turned on.
IT IS INTERESTING:  You asked: What is the hardest subject in electrical engineering?

3.08.2018

How long does an AC fan motor last?

The average lifespan of an AC fan motor is about 12 years. An AC fan motor can last more than 12 years if it’s kept clean and cooled as needed.

How much does it cost to replace a AC condenser fan motor?

AC Fan Motors Cost

Replacing the condenser fan motor in an AC unit costs $400 on average, including labor. It might cost only $300 but could cost up to $600. However, if your AC is still under warranty the cost of the part is covered (but usually not the labor).

What happens when condenser fan fails?

When the condenser overheats, all of the components of the AC system will begin to overheat until they eventually get hot enough to burn and emit an odor. … A failed fan will not only fail to produce cold air, but can even result in damage to the AC system due to overheating.

What does a bad blower motor sound like?

You might hear this as a noise coming from directly behind the vent, perhaps a light slapping, or a sudden pop before you notice a problem with airflow. Whirring noises might also result from a bad bearing in the motor. … This is a telltale sign of a bad blower motor.

What causes fan motor failure?

The main causes of failure are loss of lubricant, a failed run capacitor, a failed bearing in a belt drive, a little water dripping into the windings or a voltage problem. … Because of the heat, probably the most common type of failure is caused by the lack of lubrication of the bearings.

IT IS INTERESTING:  Quick Answer: What will happen if we increase the number of turns of a coil of a motor?

How can you tell if a fan capacitor is bad?

The capacitor is usually a black box inside the switch housing of the fan. If the case appears burnt or melted in any way, that is also the sign of a bad capacitor and it should be replaced. Keep in mind that there may be other components in the circuit with the defective capacitor.

What to do if AC fan is not working?

Turn off the AC from the thermostat and the circuit breaker. Check the fan for any debris or components it is contacting while spinning. Using your kick-start stick to manually spin the fan makes this easier. If you notice any debris, clear it out, turn everything back on, and listen to it again while it’s running.

What would cause a fan to stop working?

If your ceiling fan stopped working or is not turning on, it could be because it isn’t receiving any electricity. This could be because the circuit breaker has tripped or is off. … Your ceiling fan could also stop working due to internal defects namely shot ball bearings or an overheated motor.

How much does it cost to replace a condenser fan?

The average cost of a condenser fan motor repair is between $300 and $500. This price includes both the price of the part and the labor to have it installed. However, it needs to be replaced right away to prevent further damage to the compressor.

How much is a fan capacitor?

The price for a new blower capacitor is typically between $9 and $12. This provides the necessary power to spin the blower motor so the fan moves in the furnace.

IT IS INTERESTING:  Can you drive car with engine flush in?
Service station